Bis(p-aminophenyl) Ether is a reagent used in the preparation of polyimide-silica composite membranes for gas separation techniques. In addition, it is used in the synthesis of polymer films for electrolyte membranes. Dyes and metabolites, Environmental Testing
4,40-Oxydianiline is a white crystalline solid,or a beige powder. Molecular weight =200.26; Boilingpoint ≥300℃ (sublimes); Freezing/Meltingpoint = 186-187℃; Flash point =219℃. Very slightlysoluble in water.
4,40′-Oxydianiline is a white crystalline solid,
or a beige powder.
4-Aminophenyl ether is a resin used in the manufacture of a variety of industrial products.
For example as, insulating varnishes, flame-retardant fi bers, wire enamels, coatings, and
fi lms. It is also used for the manufacture of other fi re-resistant products.
4,4＇-Oxydianiline has been used to produce polyimide resins.
4,4'-diaminodiphenylether be used for preparation polyimide and epoxy resin material.
Bis(p-aminophenyl) Ether is a reagent used in the preparation of polyimide-silica composite membranes for gas separation techniques. In addition, it is used in the synthesis of polymer films for elect
rolyte membranes.
4-Aminophenyl ether was produced in relatively large volume
(on the order of 100,000–1,000,000 lb) in the 1970s but
has since declined significantly. The compound is used
primarily in the production of polyimide and polyesterimide
resins. These resins are used in the manufacture of temperature-
resistant products such as wire enamels, coatings, film,
insulating varnishes, and flame-retardant fibers.
ChEBI: 4-Aminophenyl ether is an aromatic ether.
Odorless colorless crystals or an odorless fine, beige powder.
4,4'-Oxydianiline oxidizes readily in air to form unstable peroxides that may explode spontaneously [Bretherick, 1979 p.151-154, 164]. A mixture of liquid air and diethyl ether exploded spontaneously [MCA Case History 616(1960)].
4-Aminophenyl ether is highly toxic to animals. There is suffi cient evidence as a carcinogenicity and has caused adenomas and carcinomas in the thyroid and liver of experimental rats.
4,4'-Oxydianiline is combustible.
Flammability and Explosibility
Not classified
Confirmed carcinogen with experimental carcinogenic, neoplastigenic, and tumorigenic data. Poison by intraperitoneal route. Moderately toxic by ingestion. Mutation data reported. When heated to decomposition it emits toxic fumes of NOx
Intermediate in the manufacture of
high-temperature-resistant, straight polyimide and poly
(esterimide) resins capable of withstanding temperatures of
Up to 480°C for short periods or 260°C for prolonged periods
of time. Some p-phenylenediamine compounds have
been used as rubber components, and DFG warns of danger
of skin sensitization.
Skin Contact: Flood all areas of body that havecontacted the substance with water. Do not wait to removecontaminated clothing; do it under the water stream. Usesoap to help assure removal. Isolate contaminated clothingwhen removed to prevent contact by others. EyeContact: Remove any contact lenses at once. Immediatelyflush eyes well with copious quantities of water or normalsaline for at least 20-30 min. Seek medical attention.Inhalation: Leave contaminated area immediately; breathefresh air. Proper respiratory protection must be supplied toany rescuers. If coughing, difficult breathing, or any othersymptoms develop, seek medical attention at once, even ifsymptoms develop many hours after exposure. Ingestion:Contact a physician, hospital, or poison center at once. Ifthe victim is unconscious or convulsing, do not inducevomiting or give anything by mouth. Assure that thepatient’s airway is open and lay him on his side with hishead lower than his body and transport immediately to amedical facility. If conscious and not convulsing, give aglass of water to dilute the substance. Vomiting should notbe induced without a physician’s advice.
4,4′-Oxydianiline is reasonably anticipated to be a human carcinogenbased on sufficient evidence of carcinogenicity from studies in experimental animals.
Color Code—Blue: Health Hazard/Poison: Storein a secure poison location. Prior to working with thischemical you should be trained on its proper handling andstorage. Store in a refrigerator under an inert atmosphere.Protect from exposure to light and oxidizing agents. A regulated, marked area should be established where this chemical is handled, used, or stored in compliance with OSHAStandard 1910.1045.
UN2811 Toxic solids, organic, n.o.s., Hazard
Class: 6.1; Labels: 6.1-Poisonous materials, Technical Name
Required. UN3077 Environmentally hazardous substances,
solid, n.o.s., Hazard class: 9; Labels: 9-Miscellaneous hazardous
material, Technical Name Required.
Incompatible with oxidizers (chlorates,
nitrates, peroxides, permanganates, perchlorates, chlorine,
bromine, fluorine, etc.); contact may cause fires or explosions.
Keep away from alkaline materials, strong bases,
strong acids, oxoacids, and epoxides. Slowly hydrolyzes in
water, releasing ammonia, and forming acetate salts.
Decomposes at 265C releasing toxic oxides of nitrogen,
sulfur, and carbon. Decomposed by strong ultraviolet light.
Incineration with provision
for nitrogen oxides removal from flue gases.
