110-75-8

Liquid boiling at 209°C. Density 1.048 g/cm3 and insoluble in water. Hence sinks in water. Flash point 142°F. Toxic.

2-CHLOROETHYL VINYL ETHER(110-75-8) forms salts with strong acids and addition complexes with Lewis acids. May react violently with strong oxidizing agents. Typically stabilized against polyermizable by addition of triethanolamine.

Flammable. Oxidizes readily in air to form unstable peroxides that may explode spontaneously [Bretherick, 1979 p.151-154, 164]. Insoluble in water.

Moderate fire risk. Combustible.

ACUTE/CHRONIC HAZARDS: Dangerous when exposed to heat, flame, or oxidizers. Moderately toxic by ingestion and inhalation. DO NOT INDUCE VOMITING. Volatile chemicals have a high risk of being aspirated into the victim's lungs during vomiting which increases the medical problems. If the victim is conscious and not convulsing, give 1 or 2 glasses of water to dilute the chemical and IMMEDIATELY call a hospital or poison control center. IMMEDIATELY transport the victim to a hospital. If the victim is convulsing or unconscious, do not give anything by mouth, ensure that the victim's airway is open and lay the victim on his/her side with the head lower than the body. DO NOT INDUCE VOMITING. IMMEDIATELY transport the victim to a hospital.

2-Chloroethyl vinyl ether is used in the manufacture of anesthetics, sedatives, and cellulose ethers. The number of potentially exposed individuals is greatest for the following areas: fabricated metal products; wholesale trade; leather, rubber and plastic; and chemical products.

Highly flammable.

If this chemical gets into the eyes, remove any contact lenses at once and irrigate immediately for at least 15 minutes, occasionally lifting upper and lower lids. Seek medical attention immediately. If this chemical contacts the skin, remove contaminated clothing and wash immediately with soap and water. Seek medical attention immediately. If this chemical has been inhaled, remove from exposure, begin rescue breathing (using universal precautions, including resuscitation mask) if breathing has stopped and CPR if heart action has stopped. Transfer promptly to a medical facility. When this chemical has been swallowed, get medical attention. Give large quantities of water and induce vomiting. Do not make an unconscious person vomit.

UN1992 Flammable liquids, toxic, n.o.s., Hazard Class: 3; Labels: 3-Flammable liquid, 6.1-Poisonous materials, Technical Name Required.

Peroxidizable Compound; may form unstable peroxides that can cause explosive polymerization. Stabilizer: 300 ppm triethanolamine and 50 ppm MEHQ (monomethyl ether of hydroquinone). 2-Chloroethyl vinyl ether forms explosive mixture with air. May accumulate static electrical charges, and may cause ignition of its vapors. Contact with oxidizing materials may cause fire or explosion hazard. Stabilizer: 300 ppm triethanolamine & 50 ppm MEHQ (monomethyl ether of hydroquinone).

2-Chloroethyl vinyl ether is a highly flammable, colorless liquid. Molecular weight =106.55; Boilingpoint =108.7℃; Freezing/Melting point =70℃; Flashpoint =27℃. Hazard Identification (based on NFPA 704 MRating System): Health 2, Flammability 3, Reactivity 2.Slightly soluble in water

2-Chloroethyl vinyl ether is a highly flammable, colorless liquid.

CLEAR COLORLESS TO LIGHT YELLOW LIQUID

Residues may be packaged in epoxy-lined drums and disposed of by high temperature incineration with HCl scrubbing of effluent gases.

Biological. When 2-chloroethyl vinyl ether was statically incubated in the dark at 25 °C with yeast extract and settled domestic wastewater inoculum, significant biodegradation with rapid adaptation was observed. At concentrations of 5 and 10 mg/L, complete degradation was observed after 21 d (Tabak et al., 1981).
Chemical/Physical. Chlorination of 2-chloroethyl vinyl ether to α-chloroethyl ethyl ether or β-chloroethyl ethyl ether may occur in water treatment facilities. The alpha compound is very unstable in water and decomposes almost as fast as it is formed (Summers, 1955). Although stable in NaOH solutions, in dilute acid solutions hydrolysis yields acetaldehyde and chlorohydrin (Windholz et al., 1983). At pH 7 and 25 °C, the hydrolysis half-life is 175 d (Jones and Wood, 1964).
At influent concentrations of 10.0, 1.0, 0.1, and 0.01 mg/L, the GAC adsorption capacities at pH 5.4 were 25, 3.9, 0.6, and 0.1 mg/g, respectively (Dobbs and Cohen, 1980).

Color Code—Red: Flammability Hazard: Store ina flammable liquid storage area or approved cabinet awayfrom ignition sources and corrosive and reactive materials.Prior to working with this chemical you should be trainedon its proper handling and storage. Before entering confinedspace where 2-chloroethyl vinyl ether may be present,check to make sure that an explosive concentration does notexist. Store in tightly closed containers in a cool, well-ventilated area. Metal containers involving the transfer of thischemical should be grounded and bonded. Where possible,automatically pump liquid from drums or other storage containers to process containers. Drums must be equipped withself-closing valves, pressure vacuum bungs, and flamearresters. Use only nonsparking tools and equipment, especially when opening and closing containers of this chemical. Sources of ignition, such as smoking and open flames,are prohibited where this chemical is used, handled, orstored in a manner that could create a potential fire orexplosion hazard.

Wash the ether repeatedly with equal volumes of water made slightly alkaline with KOH, dry with sodium, and distil it under vacuum. Stabilise it with ~0.01% of triethanolamine. [Beilstein 1 IV 2051.] TOXIC.