1-Methoxypropan-2-ol

Gefahreninformationscode (GHS)

• Bildanzeige (GHS)

  

• Alarmwort

  Warnung

• Gefahrenhinweise

  H226：Flüssigkeit und Dampf entzündbar.

  H336：Kann Schläfrigkeit und Benommenheit verursachen.

• Sicherheit

  P210：Von Hitze, heißen Oberflächen, Funken, offenen Flammen und anderen Zündquellenarten fernhalten. Nicht rauchen.

  P233：Behälter dicht verschlossen halten.

  P240：Behälter und zu befüllende Anlage erden.

  P241：Explosionsgeschützte [elektrische/Lüftungs-/ Beleuchtungs-/...] Geräte verwenden.

  P242：Nur funkenfreies Werkzeug verwenden.

  P243：Maßnahmen gegen elektrostatische Entladungen treffen.

1-Methoxy-2-propanol Chemische Eigenschaften,Einsatz,Produktion Methoden

• ERSCHEINUNGSBILD

  FARBLOSE FLüSSIGKEIT MIT CHARAKTERISTISCHEM GERUCH.

• CHEMISCHE GEFAHREN

  Bildung explosionsfähiger Peroxide wahrscheinlich. Reagiert mit starken Oxidationsmitteln, Säurechloriden, Säureanhydriden, Aluminium und Kupfer.

• ARBEITSPLATZGRENZWERTE

  TLV: 100 ppm (als TWA); 150 ppm (als STEL); (ACGIH 2005).
  MAK: 100 ppm, 370 mg/m? Spitzenbegrenzung: überschreitungsfaktor I(2); Schwangerschaft: Gruppe C; (DFG 2008).
  EG Arbeitsplatz-Richtgrenzwerte: 100 ppm, 375 mg/m?(als TWA); 150 ppm, 568 mg/m?(als STEL); Hautresorption (EU 2000).
  

• AUFNAHMEWEGE

  Aufnahme in den Körper durch Inhalation der Dämpfe oder des Aerosols, über die Haut und durch Verschlucken.

• INHALATIONSGEFAHREN

  Beim Verdampfen bei 20°C tritt langsam eine gesundheitsschädliche Kontamination der Luft ein.

• WIRKUNGEN BEI KURZZEITEXPOSITION

  WIRKUNGEN BEI KURZZEITEXPOSITION:
  Die Substanz und der Dampf (in hoher Konzentration) reizen die Augen, die Haut und die Atemwege. Exposition gegenüber sehr hohen Konzentrationen kann zu Depression des Zentralnervensystems führen.

• WIRKUNGEN NACH WIEDERHOLTER ODER LANGZEITEXPOSITION

  Die Flüssigkeit entfettet die Haut.

• LECKAGE

  Ausgelaufene Flüssigkeit möglichst in abdichtbaren Behältern sammeln. Reste mit viel Wasser wegspülen.

• R-Sätze Betriebsanweisung:

  R10:Entzündlich.

• S-Sätze Betriebsanweisung:

  S24:Berührung mit der Haut vermeiden.
  S26:Bei Berührung mit den Augen sofort gründlich mit Wasser abspülen und Arzt konsultieren.
  S24/25:Berührung mit den Augen und der Haut vermeiden.

• Chemische Eigenschaften

  Propylene glycol monomethyl ether is a colorless liquid with a sweet ether-like odor and bitter taste. It is soluble in water, ether, acetone, and benzene.

• Chemische Eigenschaften

  colourless liquid

• Verwenden

  1-Methoxy-2-propanol is used as a solvent for cellulose, acrylics, dyes, inks, and cellophane.

• Verwenden

  1-Methoxy-2-propanol acts as a good biological indicator.

• Verwenden

  1-Methoxy-2-propanol is primarily used in the manufacture of lacquers and paints, as an anti-freeze in industrial engines, a tailing agent for inks used on very high-speed presses, a coupling agent for resins and dyes in waterbased inks, and a solvent for celluloses, acrylics, dyes, inks, and stains. It is also used in cleaning products such as glass and rug cleaners, carbon and grease removers, and paint and varnish removers; and in pesticide formulations as a solvent for applications to crops and animals.

• Verwenden

  A glycol ether and a good biological indicator of exposure.

• Verwenden

  1-Methoxy-2-propanol is mainly used as solvent, dispersant and diluent, as well as fuel antifreeze, extractant, etc. Used as solvent of nitrocellulose, compounding agent of brake oil and detergent, etc. Widely used in coatings and cleaners. It can be used as the active solvent of water-based coatings; Active solvent and coupling agent of solvent based printing ink; Solvent for ballpoint pens and pens; Coupling agents and solvents for household and industrial cleaners, derusting agents and hard surface cleaners; Solvents for agricultural pesticides; Mixed with propylene glycol n-butyl ether for glass cleaner formula.

• Allgemeine Beschreibung

  A colorless liquid. Flash point near 89°F. Less dense than water. Contact irritates skin, eyes and mucous membranes. Prolonged exposure to vapors may cause coughing, shortness of breath, dizziness and intoxication. Vapors heavier than air. Used as a solvent and as an antifreeze agent.

• Air & Water Reaktionen

  Highly flammable. Soluble in water. Oxidizes readily in air to form unstable peroxides that may explode spontaneously [Bretherick 1979 p.151-154, 164].

• Reaktivität anzeigen

  1-Methoxy-2-propanol is a methoxy alcohol derivative. The ether being relatively unreactive. Flammable and/or toxic gases are generated by the combination of alcohols with alkali metals, nitrides, and strong reducing agents. They react with oxoacids and carboxylic acids to form esters plus water. Oxidizing agents convert them to aldehydes or ketones. Alcohols exhibit both weak acid and weak base behavior. They may initiate the polymerization of isocyanates and epoxides.

• Hazard

  Flammable, moderate fire risk. TLV: 100 ppm; STEL 150 ppm.

• Health Hazard

  1-Methoxy-2-propanol is a mild toxicant. The toxicity is lower than that of the methyl, ethyl, and butyl ethers of ethylene glycol. The toxic symptoms from inhaling high concentrations are nausea, vomiting, and general anesthetic effects. In humans, toxic effects may be felt at exposure to a level of 3000–4000 ppm.The oral and dermal toxicities in test animals were low. The effects were mild depression of the central nervous system and a slight change in liver and kidney. The recovery was rapid. Irritant actions on the skin and eyes of rabbits were low
  LC50 value (rats): 7000 ppm /6 h
  LD50 value (rats): 5660 mg/kg.
  

• Health Hazard

  VAPOR: Irritating to eyes, nose, and throat. LIQUID: Irritating to skin and eyes.

• Brandgefahr

  FLAMMABLE. Flashback along vapor trail may occur. Vapor may explode if ignited in an enclosed area.

• Flammability and Explosibility

  Flammable

• Sicherheitsprofil

  Moderately toxic by intravenous route. Mildly toxic by ingestion, inhalation, and skin contact. Human systemic effects by inhalation: general anesthesia, nausea. A skin and eye irritant. An experimental teratogen. Many glycol ethers have dangerous human reproductive effects. Very dangerous fire hazard when exposed to heat or flame; can react with oxidizing materials. To fight fire, use foam, CO2, dry chemical. When heated to decomposition it emits acrid smoke and irritating fumes. Used as a solvent and in solvent-sealing of cellophane. See also GLYCOL ETHERS and ETHYLENE GLYCOL MONOMETHYL ETHER.

• Synthese

  1-Methoxy-2-propanol is used as a reagent in the synthesis of 2-amino-3-carboxy-4-phenylthiophenes, which acts as a protein kinase C inhibitors. It is also used as a reagent in the synthesis of metolachlor.

• mögliche Exposition

  Propylene glycol monomethyl ether is used as a solvent for coatings; cellulose esters and acrylics; acrylics dyes; inks, and stains. It may also be used as a heat-transfer fluid.

• Versand/Shipping

  UN3092 1-Methoxy-2-propanol, Hazard Class: 3; Labels: 3-Flammable liquid.

• Advantages

  1-Methoxy-2-propanol has been used as an antifreeze material, principally in ebullient cooling systems and in some heavy-duty diesel engines. Because an azeotrope is formed between 1-methoxy-2-propanol and water, freeze protection also is provided in the vapor phase in ebullient cooling applications. On the other hand, 1-methoxy-2-propanol is more volatile and is more readily expelled along with water vapor through the crankcase vent system. 1-Methoxy-2-propanol also maintains lower metal temperatures than comparative glycolbased coolants. This was an advantage in rotary engines.
  

• Toxicity evaluation

  Contact irritates skin, eyes and mucous membranes. Prolonged exposure to vapors may cause coughing, shortness of breath, dizziness and intoxication. Vapors heavier than air. Used as a solvent and as an antifreeze agent. The oral LD50 of rats was 6.6g/kg. The skin irritation is not obvious, but the toxic dose can be absorbed through the skin. The main manifestations of animal poisoning were inhibition and incomplete anesthesia. Half of the rats died when they were exposed to steam concentration of 40.18g/m3 for 5 ~ 6 hours. the impact of 1-methoxypropanol-2 (MEP) for the stimulation of an inflammatory response in human respiratory mucosa, we exposed 22 primary cell cultures of nasal respiratory epithelia of healthy individuals to MEP concentrations at the level of the German MAK-value (100ppm) and to the 10-fold concentration (1000ppm).

• Inkompatibilitäten

  Vapor may form explosive mixture with air. Incompatible with oxidizers (chlorates, nitrates, peroxides, permanganates, perchlorates, chlorine, bromine, fluorine, etc.); contact may cause fires or explosions. Keep away from alkaline materials, strong bases, strong acids, oxoacids, epoxides, acid chlorides, acid anhydrides, isocya- nates, aluminum, and copper. Hygroscopic (i.e., absorbs moisture from the air). May slowly form reactive peroxides during prolonged storage or on exposure to air and light.

• Waste disposal

  Dissolve or mix the material with a combustible solvent and burn in a chemical incinerator equipped with an afterburner and scrubber. All federal, state, and local environmental regulations must be observed.

1-Methoxy-2-propanol Upstream-Materialien And Downstream Produkte

1-Methoxypropan-2-ol Anbieter Lieferant Produzent Hersteller Vertrieb Händler.

Global(666)Suppliers

107-98-2, 1-Methoxy-2-propanol Verwandte Suche: