케텐

한글명:케텐

카스 번호463-51-4

상품명:ketene

CBNumberCB9934768

분자식C2H2O

포뮬러 무게42.04

MOL 파일463-51-4.mol

동의어(한글)

케텐

화학적 성질

녹는점	-150°
끓는 점	bp -56°
밀도	0.6600
굴절률	1.3040 (estimate)
물리적 상태	가스
노출 한도	TLV-TWA 0.9 mg/m³ (0.5 ppm); STEL 3.0 mg/m³ (1.5 ppm) (ACGIH); IDLH 50 ppm (NIOSH).
EPA	Ketene (463-51-4)

위험 및 안전 성명

유엔번호(UN No.)	1955
OEB	C
OEL	TWA: 0.5 ppm (0.9 mg/m3), STEL: 1.5 ppm (3 mg/m3)
위험 등급	2.3
유해 물질 데이터	463-51-4(Hazardous Substances Data)
IDLA	5 ppm

그림문자(GHS)

그림문자(GHS)
신호 어

Danger
유해·위험 문구

H220：극인화성 가스

H315：피부에 자극을 일으킴

H318：눈에 심한 손상을 일으킴

H330：흡입하면 치명적임

H335：호흡 자극성을 일으킬 수 있음
예방조치문구

P210：열·스파크·화염·고열로부터 멀리하시오 - 금연 하시오.

P260：분진·흄·가스·미스트·증기·...·스프레이를 흡입하지 마시오.

P264：취급 후에는 손을 철저히 씻으시오.

P264：취급 후에는 손을 철저히 씻으시오.

P271：옥외 또는 환기가 잘 되는 곳에서만 취급하시오.

P280：보호장갑/보호의/보안경/안면보호구를 착용하시오.

P284：호흡 보호구를 착용하시오.

P302+P352：피부에 묻으면 다량의 물로 씻으시오.

P304+P340：흡입하면 신선한 공기가 있는 곳으로 옮기고 호흡하기 쉬운 자세로 안정을 취하시오.

P305+P351+P338：눈에 묻으면 몇 분간 물로 조심해서 씻으시오. 가능하면 콘택트렌즈를 제거하시오. 계속 씻으시오.

P310：즉시 의료기관(의사)의 진찰을 받으시오. 삼켰다면 즉시 의료기관(의사)의 도움을 받으시오.

P320：긴급히 (…) 처치를 하시오.

P321：(…) 처치를 하시오.

P332+P313：피부 자극이 생기면 의학적인 조치· 조언을 구하시오.

P362：오염된 의복을 벗고 세척 후에 재사용하기

P377：누출성 가스 화재 시 : 누출을 안전하게 막을 수 없다면, 불을 끄려하지 마시오.

P381：누출의 경우, 모든 점화원을 제거하시오.

P403：환기가 잘 되는 곳에 보관하시오.

P403+P233：용기는 환기가 잘 되는 곳에 단단히 밀폐하여 저장하시오.

P405：밀봉하여 저장하시오.

P501：...에 내용물 / 용기를 폐기 하시오.

케텐 화학적 특성, 용도, 생산

화학적 성질
Colorless gas with a sharp penetrating odor;liquefies at -56°C (-68.8°F); solidifies at-151°C (-239.8°F); soluble in alcohol andacetone, decomposed by water.
용도
For the conversion of higher acids into their anhydrides; for acetylation in the manufacture of cellulose acetate and aspirin.
생산 방법
Ketene may be prepared also by pyrolysis of acetic anhydride or phenyl acetate or diketene. Other sources are quite unsatisfactory from a standpoint of yield. Small quantities may be made conveniently by heating acetone in a “ketene lamp.” This is a glass apparatus containing a Nichrome filament, heated electrically to red heat. Larger amounts are made by passing acetone or acetic acid through a tube at 700 °C. A very brief contact time is required, so that much of the acetone is undecomposed and has to be condensed and recycled. Also, it is imperative that the reaction tube be of inert material such as porcelain, glass, quartz, copper or stainless steel. A copper tube, if used, should be protected from oxidation by an iron sheath. Inert packing may be used (glass, vanadium pentoxide, porcelain), but just as good yields are obtained with empty tubes. No catalyst is known which accelerates this decomposition at significantly lower temperatures.
건강위험
Ketene is a highly toxic gas. It causes severeirritation to the eyes, nose, throat, and skin.Exposure to 10–15 ppm for several minutescan injure the respiratory tract. It causespulmonary edema. A 30-minute exposure to23 ppm was lethal to mice and a 10-minuteexposure to 200 and 750 ppm caused deathto monkeys and cats.
화재위험
Ketene in its gaseous state should be flammable and explosive in air. The pure compound, however, polymerizes readily and cannot be stored as a gas. Its flash point and LEL and UEL values are not reported. It can react violently with oxidizers and many organic compounds. Its small size and the olefinic unsaturation impart further reactivity to the molecule.
Purification Methods
Ketene is prepared by pyrolysis of acetic anhydride. Purify it by passing through a trap at -75o and collecting in a liquid-nitrogen-cooled trap. Ethylene is removed by evacuating the ethylene in an isopentane-liquid-nitrogen slush pack at -160o. Store it at room temperature in a suitable container in the dark or better at -80o, but do not store it under pressure as it may EXPLODE. It is a strong IRRITANT when inhaled and is as poisonous as phosgene. See diketene in “Heterocyclic Compounds”, Chapter 4. [Hurd Org Synth Coll Vol I 330 1941, Andreades & Carlson Org Synth Coll Vol V 679 1973.]

케텐 준비 용품 및 원자재

케텐 공급 업체

케텐 관련 검색

Send Inquriy