イソブチロニトリル

危険有害性情報のコード(GHS)

• 絵表示(GHS)

  

• 注意喚起語

  Danger

• 危険有害性情報

  H225：引火性の高い液体および蒸気

• 注意書き

  P210：熱/火花/裸火/高温のもののような着火源から遠ざ けること。－禁煙。

  P233：容器を密閉しておくこと。

  P240：容器を接地すること/アースをとること。

  P280：保護手袋/保護衣/保護眼鏡/保護面を着用するこ と。

  P303+P361+P353：皮膚（または髪）に付着した場合：直ちに汚染された衣 類をすべて脱ぐこと/取り除くこと。皮膚を流水/シャワー で洗うこと。

イソブチロニトリル 価格

イソブチロニトリル 化学特性,用途語,生産方法

• 外観

  無色～うすい黄色, 澄明の液体

• 溶解性

  水に微溶 (3.5%, 20℃)。エタノール, エーテルに易溶。

• 化学的特性

  Colorless liquid with a foul odor. Insoluble in water, easily soluble in ethanol and ether.

• 使用

  Isobutyronitrile can be derived from isobutyraldehyde. It is used in organic synthesis, as a catalyst in the polymerization of ethylene and in the petroleum industry as a gasoline additive. Isobutyronitrile is also used to synthesize the intermediate 2-isopropyl-4-methyl-6-hydroxypyrimidine of the organophosphorus insecticide diazinon.

• 調製方法

  Isobutyronitrile is prepared from isobutyraldehyde by cyanation with ammonia.

• 調製方法

  Isobutyronitrile is usually obtained by the catalytic gas-phase reaction of isobutyraldehyde or isobutanol with ammonia. Its major use is the synthesis of the insecticide diazinon.

• 一般的な説明

  A clear colorless liquid. Flash point 47°F. Less dense than water. Vapors heavier than air. Toxic oxides of nitrogen produced during combustion.

• 空気と水の反応

  Highly flammable. Slightly soluble in water.

• 反応プロフィール

  Isobutyronitrile is incompatible with the following: Oxidizers, reducing agents, strong acids & bases .

• 危険性

  Toxic by ingestion, inhalation, and skin absorption.

• 健康ハザード

  Isobutyronitrile is considered highly hazardous and full precautions should be taken to prevent skin contact or inhalation of vapor. Inhaled isobutyronitrile is about 2.4 times as toxic as acetonitrile in rats. may be fatal if inhaled, swallowed, or absorbed through skin. Contact may cause burns to skin and eyes. (Non-Specific -- Nitriles) Primarily, they are skin and eye irritants. Large doses cause collapse and stop breathing. In order to protect workers, the recommended TWA limit is obtained by dividing that for acetonitrile by the factor 2.4. NIOSH has therefore recommended that employee exposure should not exceed 8 p.p.m. (22 mg/m3) for either compound as a TLV-TWA.

• 火災危険

  Vapor may explode if ignited in an enclosed area. Toxic oxides of nitrogen are produced during combustion. Isobutyronitrile is a flammable/combustible material and may be ignited by heat, sparks, or flames. Vapors may travel to a source of ignition and flash back. Container may explode in heat of fire. Vapor explosion and poison hazard indoors, outdoors or in sewers. Runoff to sewer may create fire or explosion hazard. Hazardous polymerization may not occur.

• 代謝

  Thiocyanate was present in the urine of rats dosed orally with isobutyronitrile.

• 純化方法

  Shake the nitrile with conc HCl (to remove isonitriles), then with water and aqueous NaHCO3. After a preliminary drying with silica gel or Linde type 4A molecular sieves, it is shaken or stirred with CaH2 until hydrogen evolution ceases, then decanted and distilled from P2O5 (not more than 5g/L, to minimize gel formation) or Drierite (b 101-103o/760mm). Finally it is refluxed with, and slowly distilled from CaH2 (5g/L), taking precautions to exclude moisture. [Beilstein 2 H 294, 2 I 129, 2 II 263, 2 III 655, 2 IV 853.]

イソブチロニトリル 上流と下流の製品情報

イソブチロニトリル スペクトルデータ(¹HNMR、¹³CNMR、ESR、IR1、IR2、MS、Raman)

78-82-0, イソブチロニトリル キーワード