ジ-tert-ブチルペルオキシド

危険有害性情報のコード(GHS)

• 絵表示(GHS)

  

• 注意喚起語

  Danger

• 危険有害性情報

  H225：引火性の高い液体および蒸気

  H242：熱すると火災のおそれ

  H341：遺伝性疾患のおそれの疑い

  H412：長期的影響により水生生物に有害

• 注意書き

  P210：熱/火花/裸火/高温のもののような着火源から遠ざ けること。－禁煙。

  P220：衣類/．．．/可燃物から遠ざけること。

  P273：環境への放出を避けること。

  P280：保護手袋/保護衣/保護眼鏡/保護面を着用するこ と。

  P410：日光から遮断すること。

  P411+P235：．．． ０C 以下の温度で保管すること。涼しいと ころに置くこと。

ジ-tert-ブチルペルオキシド 価格

ジ-tert-ブチルペルオキシド 化学特性,用途語,生産方法

• 外観

  無色～うすい黄色透明液体

• 用途

  重合開始剤、硬化剤、架橋剤および有機合成試薬

• 説明

  Di-tert-butyl peroxide is a clear, water-white liquid. It has a specific gravity of 0.79, which is lighter than water, and it will float on the surface. It is nonpolar and insoluble in water. Di-tert-butyl peroxide is a strong oxidizer and may ignite organic materials or explode if shocked or in contact with reducing agents. In addition to being an oxidizer, Di-tert-butyl peroxide is highly flammable. It has a boiling point of 231°F (110°C) and a flash point of 65°F (18°C). The NFPA 704 designation is health 3, flammability 2, and reactivity 4. The prefix “oxy” for oxidizer is placed in the white section at the bottom of the 704 diamond.

• 一般的な説明

  Di-tert-butyl peroxide is a clear colorless liquid. (NTP, 1992)

• 反応プロフィール

  The explosive instability of the lower dialkyl peroxides (e.g., dimethyl peroxide) and 1,1-bis-peroxides decreases rapidly with increasing chain length and degree of branching, the di-tert-alkyl derivatives being amongst the most stable class of peroxides. Though many 1,1-bis-peroxides have been reported, few have been purified because of the higher explosion hazards compared with the monofunctional peroxides. Di-tert-butyl peroxide is unlikely that this derivative would be particularly unstable compared to other peroxides in it's class, Bretherick 1979v.

• 健康ハザード

  DTBP is slightly toxic by inhalation andin general exhibits low to very low toxicityby other routes. However, toxic effectsare observed only at very high concentrations.Rats exposed to 4103-ppm vapor developedhead and neck tremor after 10 minutesof exposure (Floyd and Stockinger 1958).Other symptoms were weakness, hyperactivity,and labored breathing. However, theanimals recovered fully in 1 hour.
  LD₅₀ value, intraperitoneal rats): 3210 mg/kg
  DTBP is nonirritating to the skin and mildon the eyes. It is reported to cause lungand blood tumors in mice (NIOSH 1986).However, its carcinogenicity is not yet fullyestablished.

• 火災危険

  Highly flammable and reactive; flash point 18°C (64.4°F); vapor pressure 19.5 torr at 20°C (68°F); vapor density 5.03. Its decomposition products are ethane and acetone, which enhance the fire hazard. Use a water spray to fight fire and to keep the containers cool.
  DTBP forms an explosive mixture with air. The explosive range is not reported. Its decomposition products may explode above its boiling point, 111°C (231.8°F). However, as it is thermally stable and shock insensitive, its explosion hazard is much lower. It may, however, react with explosive violence when in contact with easily oxidizable substances.

• 発がん性

  A single exposure (route unspecified, but probably subcutaneous (SC)) of 14.6 mg (～365 mg/kg) produced unconvincing evidence for carcinogenicity owing to the lack of controls in 50 mice observed for more than 80 weeks. Of 35 survivors, 7 (20%) had malignant blood tumors (lymphomas) and 1 had a benign lung tumor (pulmonary adenoma) (93, 7a). Owing to its poor design, this study should be judged inadequate to determine carcinogenicity.

• 貯蔵

  Store in a cool and well-ventilated areaisolated from easily oxidizable materials.Protect against physical damage. Shippingcontainers are amber glass and polyethylenebottles or steel drums not exceeding 100-lbcapacity.

• 純化方法

  Wash the peroxide with aqueous AgNO3 to remove olefinic impurities, water and dry (MgSO4). Free it from tert-butyl hydroperoxide by passage through an alumina column [Jackson et al. J Am Chem Soc 107 208 1985], and if necessary two high vacuum distillations from room temperature to a liquid-air trap [Offenbach & Tobolsky J Am Chem Soc 79 278 1957]. [Beilstein 1 IV 1619.] The necessary protection from EXPLOSION should be used.

• 廃棄物の処理

  Di-tert-butyl peroxide is disposed on the ground in a remotearea and ignited with a long torch. 10%NaOH may be used to wash empty containers.

ジ-tert-ブチルペルオキシド 上流と下流の製品情報

ジ-tert-ブチルペルオキシド 生産企業

Global(289)Suppliers

ジ-tert-ブチルペルオキシド スペクトルデータ(ESR、FT-IR、IR、Raman)

110-05-4, ジ-tert-ブチルペルオキシド キーワード