Dieisentrioxid

Gefahreninformationscode (GHS)

• Bildanzeige (GHS)

  

• Alarmwort

  Achtung

• Gefahrenhinweise

  H225：Flüssigkeit und Dampf leicht entzündbar.

  H318：Verursacht schwere Augenschäden.

• Sicherheit

  P210：Von Hitze, heißen Oberflächen, Funken, offenen Flammen und anderen Zündquellenarten fernhalten. Nicht rauchen.

  P280：Schutzhandschuhe/Schutzkleidung/Augenschutz tragen.

Ferric oxide Chemische Eigenschaften,Einsatz,Produktion Methoden

• ERSCHEINUNGSBILD

  RöTLICHBRAUNE BIS SCHWARZE KRISTALLE ODER PULVER.

• CHEMISCHE GEFAHREN

  Reagiert mit Kohlenmonoxidunter Explosionsgefahr.

• ARBEITSPLATZGRENZWERTE

  TLV: (Staub und Rauch, als Fe) 5 mg/m?(als TWA); Krebskategorie A4 (nicht klassifizierbar als krebserzeugend für den Menschen); (ACGIH 2005).
  MAK: (alveolengängige Fraktion des Aerosols) 1.5 mg/m? (DFG 2005).
  

• INHALATIONSGEFAHREN

  Eine belästigende Partikelkonzentration in der Luft kann beim Dispergieren schnell erreicht werden, besonders als Pulver.

• WIRKUNGEN BEI KURZZEITEXPOSITION

  WIRKUNGEN BEI KURZZEITEXPOSITION:
  Reizt möglicherweise mechanisch.

• WIRKUNGEN NACH WIEDERHOLTER ODER LANGZEITEXPOSITION

  Risiko der Lungenschädigung bei wiederholter oder längerer Exposition gegenüber Staubpartikeln. Führt zu Eisenoxidstaublunge (gutartig).

• LECKAGE

  Persönliche Schutzausrüstung: Atemschutzgerät, P1-Filter für inerte Partikel. Verschüttetes Material in abgedeckten Behältern sammeln.

• R-Sätze Betriebsanweisung:

  R36/37/38:Reizt die Augen, die Atmungsorgane und die Haut.

• S-Sätze Betriebsanweisung:

  S26:Bei Berührung mit den Augen sofort gründlich mit Wasser abspülen und Arzt konsultieren.

• Beschreibung

  Iron oxides are produced synthetically and consist essentially of anhydrous and/or hydrated iron oxides. The range of hues includesyellows, reds, browns and blacks. Food quality iron oxides are primarily distinguished from technical grades by the comparatively low levels of contamination by other metals. This is achieved by the selection and control of the source of iron and/or by the extent of chemical purification during the manufacturing process. Iron oxides have been used to color confectionery, fillings and decorations for pastry products, cheese products, fish paste, pet foods, cosmetics and pharmaceutical products.

• Chemische Eigenschaften

  Hematite is a noncombustible, black to black red or brick-red mineral (iron ore) composed mainly of ferric oxide, Fe2O3. Ferric oxide

• Occurrence

  Iron(III) oxide occurs in nature as the mineral hematite. It is the principal ore of iron from which the metal and its alloys are produced. Also, this oxide occurs in the mineral, limonite, 2Fe₂O₃?3H₂O. An important application of this compound involves producing red, orange, and yellow pigments. Other applications are in coatings for metals, steel and rubber; in ceramics; and as a catalyst for oxidation reactions.

• Verwenden

  Ferric Oxide is a nutrient and dietary supplement that is a source of iron.

• Verwenden

  Red iron oxide (Fe2O3) is an inorganic pigment of either natural or synthetic origin. It is a low chroma red with excellent durability and low cost. Synthetic pigment is made by heating iron sulfate with quicklime in a furnace. The second preparatory technique involves calcining iron sulfate in the presence of air at high temperatures. Natural and oxides of iron are mined either as the mineral hematite (Fe2O3) or as hematite in its hydrated form.

• Verwenden

  As pigment for rubber, paints, paper, linoleum, ceramics, glass; in paint for ironwork, ship hulls; as polishing agent for glass, precious metals, diamonds; in electrical resistors and semiconductors; in magnets, magnetic tapes; as catalyst; colloidal solutions as stain for polysaccharides.

• Definition

  A high-grade red pigment used as a polishing agent for glass, jewelry, etc. (2) A cosmetic prepared from dried flowers of the saf- flower.

• synthetische

  Iron(III) oxide is prepared as a reddish-brown hydrated precipitate by treating an aqueous solution of an iron(III) salt with caustic soda:
  2FeCl₃ + 6NaOH → Fe₂O₃?3H₂O + 6NaCl
  It also is obtained by thermal decomposition of iron(II) sulfate or the brown oxide hydroxide:
  2FeSO₄ → Fe₂O₃ + SO₂ + SO₃
  2FeO(OH) → Fe₂O₃ + H₂O
  The oxide is prepared in industrial scale by first precipitating iron(II) hydroxide Fe(OH)2 by treating aqueous solutions of iron(II) sulfate and caustic soda. The Fe(OH)2 is then oxidized to iron(III) hydroxide by aeration. The latter is dehydrated by heating:
  Fe₂+ (aq) + OHˉ (aq) → Fe(OH)₂(s) → 2Fe(OH)₃ → Fe₂O₃ + 3H₂O
  It also is produced by ignition of iron(III) oxalate and iron carbonyls:
  2Fe₂(C₂O₄)₃ +3O₂ → 2Fe₂O₃ + 12CO
  .

• Definition

  A black solid prepared by passing either steam or carbon dioxide over redhot iron. It may also be prepared by passing steam over heated iron(II) sulfide. Triiron tetroxide occurs in nature as the mineral magnetite. It is insoluble in water but will dissolve in acids to give a mixture of iron(II) and iron(III) salts in the ratio 1:2. Generally it is chemically unreactive; it is, however, a fairly good conductor of electricity.

• Hazard

  Pneumoconiosis. Questionable carcinogen.

• Flammability and Explosibility

  Non flammable

• mögliche Exposition

  Hematite; as an iron ore composed mainly of ferric oxide, is a major source of iron and is used as a pigment for rubber, paints, paper, linoleum, ceramics, dental restoratives; and as a polishing agent for glass and pre cious metals. It is also used in electrical resistors, semiconduc tors, magnets, and as a catalyst. Human exposure to hematite from underground hematite mining is principally through inhalation and/or ingestion of dusts. No estimates are available concerning the number of underground miners exposed.

• Erste Hilfe

  If this chemical gets into the eyes, remove anycontact lenses at once and irri gate immediately for at least15 min, occasionally lifting upper and lower lids. Seek med-ical attention immediately. If this chemical contacts theskin, remove contaminated clothing and wash immediatelywith soap and water. Seek medical attention immediately. Ifthis chemical has been inhaled, remove from exposure,begin rescue breathing (using universal precautions, includ-ing resuscitation mask) if breathing has stopped and CPR ifheart action has stopped. Transfer promptly to a medicalfacility. When this chemical has been swallowed, get medi-cal attention. Give large quantities of water and induce :vomiting. Do not make an unconscious person vomit.Note to physician: For severepoisoning，do not useBAL .[British Anti-Lewisite， dimercaprol, dithiopropanol (C3HgOS2)] as it is contraindicated or ineffective in poisoningfrom iron.

• Carcinogenicity

  Welders are typically exposed to a complex mixture of dust and fume of metallic oxides, as well as irritant gases, and are subject to mixeddust pneumoconiosis with possible loss of pulmonary function; this should not be confused with benign pneumoconiosis caused by iron oxide.1 Although an increased incidence of lung cancer has been observed among hematite miners exposed to iron oxide, presumably owing to concomitant radon gas exposure, there is no evidence that iron oxide alone is carcinogenic to man or animals.6

• Lager

  Color Code- Green: General storage may be used.Prior to working with this chemical you should be trainedonits proper handling and storage. Store in tightly closedcontainers in a cool, well-ventilatedarea. .Where possible,automatically transfer material from other storage contain-ers to process containers A regulated, marked area shouldbe established where this chemical is handled, used, orstored in compliance with OSHA Standard 1910.1045.

• Properties and Applications

  TEST ITEMS	SPECIFICATION
  APPEARANCE	DARK RED POWDER
  SHADE	CLOSE TO STANDARD
  CONTENT OF Fe 2 O 3	96% min
  pH VALUE	3-7
  OIL ABSORPTION	15-25%
  RESIDUE ON 320 MESH	0.3% max
  WATER SOLUBLE	0.3% max
  VOLATITE 105 °C	1.0% max
  TINTING STRENGTH	98-102 %

• Inkompatibilitäten

  Contact with hydrogen peroxide, ethyl ene oxide, calcium hypochlorite will cause explosion. Violent reaction with powdered aluminum; hydrazine, hydrogen trisulfide.

Ferric oxide Upstream-Materialien And Downstream Produkte

Dieisentrioxid Anbieter Lieferant Produzent Hersteller Vertrieb Händler.

Global(481)Suppliers

1309-37-1, Ferric oxide Verwandte Suche: